裝載機秋季保養注意事項中英文版

時間：2023-09-29 00:00

點擊：1440

裝載機秋季保養送走炎炎夏日，迎來清涼秋天，在秋季，裝載機應該如何保養呢？(徐州聚隆機械專業裝載機配件批發零售13585399165微信同號！

Bidding farewell to the scorching summer and welcoming the cool autumn,In the fall, how should a loader be maintained?

動力系統檢查Power System Inspection1.檢查發動機機油油位；2.檢查散熱器液位；3.對散熱器表面的灰塵雜物用高壓空氣（≤700KPa或7kg/cm2）清理散熱器管、片之間的雜物，防止散熱系統效率降低或失效；4、及時清除發動機缸頭油污。1.Check the engine oil level.2.Inspect the radiator fluid level.3.Use high-pressure air (≤700KPa ｏｒ 7kg/cm2) to clean any dust ｏｒ debris on the radiator's surface, between the radiator pipes and fins, to prevent a reduction in the efficiency ｏｒ failure of the cooling system.4.Promptly remove any oil residue ｆｒｏｍ the engine cylinder head.

傳動系統檢查Transmission System Inspection1、檢查變速箱油位，檢查并清潔變速箱呼吸器；2、檢查驅動橋油液是否充足，油液不足時及時添加；3、檢查清潔驅動橋呼吸器，保證呼吸器通道的暢通；4、檢查輪胎氣壓；5、檢查輪輞及重要部位的螺栓并進行緊固。

Check the transmission fluid level and clean the transmission breather.2.Inspect the drive axle oil level, and top up if it's low.3.Examine and clean the drive axle breather to ensure proper airflow.4.Check tire pressure.5.Inspect and tighten bolts on the wheel rims and important components.
電器系統檢查
Electrical System Inspection

1、檢查蓄電池狀態

（1）檢查蓄電池狀態指示器(電眼)：

綠色：蓄電池電量充足，可以正常啟動車輛；

黑色：蓄電池電量不足，蓄電池需補充電；

白色：蓄電池報廢，需更換。

2、檢查皮帶松緊度

（1）檢查風扇皮帶；

（2）檢查空調壓縮機皮帶。

3、檢查插頭部位確認各接插件有無松動，針腳有無腐蝕，若有異常應使用專用清洗劑處理。線路要經常檢查發現老化、破損時，必須及時防護或更換，以防止電器線路短路，釀成火災。

1.Check the battery status.

(1) Check the battery status indicator (eye):

Green: Battery charge is sufficient, and the vehicle can start normally.

Black: Battery charge is low, and the battery needs recharging.

White: Battery is faulty and needs replacement.

2.Check the tension of belts.

1) Inspect the fan belt.

(2) Inspect the air conditioning compressor belt.

3.Examine plug connections to confirm whether connectors are loose, pins are corroded. If any abnormalities are found, use a specialized cleaning agent. Electrical wiring should be regularly inspected for signs of aging ｏｒ damage, and must be adequately protected ｏｒ replaced in a timely manner to prevent electrical shorts that could lead to fires.

制動系統檢查

Brake System Inspection

1、檢查行車制動性能、檢查駐車制動性能；

2、檢查制動加力泵油位，油液不足時及時添加；

3、清理加力泵蓋表面的污泥垢，確保油杯蓋排氣孔及呼吸器通道的暢通；

4、檢查制動鉗剎車片磨損程度，磨損過多時及時進行更換；

5、對于配裝空氣干燥罐的機型，必須按照保養要求進行保養。

1.Check the driving brake performance and inspect the parking brake performance.

2.Check the brake booster pump fluid level, and top up if it's low.

3.Clean the surface of the brake booster pump cover to ensure the vent holes in the fluid cup cover and breather are clear.

4.Inspect the brake caliper and brake pad wear level, and ｒｅｐｌａｃｅ them promptly if they are excessively worn.

5.For models equipped with an air dryer tank, maintenance must be carried out according to the maintenance requirements.

上一個 |隨車吊吊機動作慢原因分析

下一個 | 起重機吊車吊鉤是否可以焊接

国产女同自拍视频_久久久久亚洲av毛片大_好男人社区在线看www观看影_最大亚洲av手机在线观看_亚洲国产欧美日韩另类_99久久精品网站_香蕉这里有精品视频在线_18禁视点击进入_综合免费无码中文_国产日韩激情综合一区

裝載機秋季保養注意事項中英文版